Skip to content
Licensed Unlicensed Requires Authentication Published by De Gruyter September 22, 2020

Evaluating critical characteristics of vegetable oil as a biodegradable insulating oil for transformer

  • Senthil Kumar Subburaj ORCID logo EMAIL logo , Madavan Rengaraj and Ravindran Mariappan

Abstract

In transformer, fuel based mineral oil is used as insulation and coolant over many years. The ecological issue related with the current liquid insulation system is the throwing away of used oil samples after drawn out service. The paper investigates the critical properties of biodegradable oil such as olive and palm oil according to international standards. After that, a small laboratory setup of 1 kVA transformer was designed for the load test with insulating fluids with olive oil and palm oil were tested. Likewise, an attempt has been made for the technical feasibility of mixing proportion was also investigated. Then, the experimental results were compared with mineral oil. Experimental analysis shows that vegetable oil’s electrical and fire resistance properties are better than the conventionally present used mineral oil. Yet, the viscosity of vegetable oil is much higher than mineral oil. Added to that, vegetable oils are exhibiting the higher amount of higher molecular fatty acids. From the load test, it is found that transformer with nature ester palm oil has a higher efficiency that of olive oil, but it is found lower efficiency than mineral oil.


Corresponding author: Senthil Kumar Subburaj, National Engineering College, Department of EEE, Kovilpatti, Tamil Nadu, 628503, India, E-mail:

  1. Author contribution: All the authors have accepted responsibility for the entire content of this submitted manuscript and approved submission.

  2. Research funding: None declared.

  3. Conflict of interest statement: The authors declare no conflicts of interest regarding this article.

References

1. Cui, Y, Ma, H, Saha, T, Ekanayake, C, Martin, D. Particle tracing modeling on moisture dynamics of oil-impregnated transformer. IET Sci Meas Technol 2016;10:335–43. https://doi.org/10.1049/iet-smt.2015.0196.Search in Google Scholar

2. Madavan, R, Balaraman, S. Comparison of antioxidant influence on mineral oil and natural ester properties under accelerated aging conditions. IEEE Trans Dielectr Electr Insul 2017;24:2800–8. https://doi.org/10.1109/tdei.2017.006527.Search in Google Scholar

3. Liao, R, Lin, Y, Zhang, Y, Xia, H. Independent effects of aged oil and aged paper on moisture evaluation of power transformers. Elec Power Compon Syst 2016;44:556–64. https://doi.org/10.1080/15325008.2015.1122104.Search in Google Scholar

4. Mariprasath, T, Kirubakaran, V. Thermal degradation analysis of Pongamia pinnata oil as alternative liquid dielectric for distribution transformer. Springer, Sadhana-Acad Proc Eng Sci 2016;41:933–8. https://doi.org/10.1007/s12046-016-0529-0.Search in Google Scholar

5. Rao, UM, Sood, YR, Jarial, RK. Performance analysis of alternate liquid dielectrics for power transformers. IEEE Trans Dielectr Electr Insul 2015;23:2475–84. https://doi.org/10.1109/TDEI.2016.7556527.Search in Google Scholar

6. Al-Amin, H, O’Brien, J, Lashbrook, M. Synthetic ester transformer fluid: a total solution to wind park transformer technology. Renew Energy. Renewable Energy Congress - XI 2013;49:33–8. https://doi.org/10.1016/j.renene.2012.01.071.Search in Google Scholar

7. Madavan, R, Balaraman, S. Investigation on effects of different types of nanoparticles on critical parameters of nano-liquid insulation systems. J Mol Liq 2017;230:437–44. https://doi.org/10.1016/j.molliq.2017.01.057.Search in Google Scholar

8. Thien, YV, Azis, N, Jasni, J, AbKadir, MZA, Yunus, R, Ishak, MT, et al. The effect of polarity on the lightning breakdown voltages of palm oil and coconut oil under a non-uniform field for transformers application. Ind Crop Prod 2016;89:250–6. https://doi.org/10.1016/j.indcrop.2016.04.061.Search in Google Scholar

9. Mehta, DM, Kundu, P, Chowdhury, A, Lakhiani, VK, Jhala, AS. A review on critical evaluation of natural ester mineral oil insulating liquid for use in transformers: part 1. IEEE Trans Dielectr Electr Insul 2016;23:873–80. https://doi.org/10.1109/tdei.2015.005370.Search in Google Scholar

10. Arroyo, OH, Fofana, I, Ryadi, M, Jalbert, J. Relationships between methanol marker and mechanical performance of electrical insulation papers for power transformers under accelerated thermal aging. IEEE Trans Dielectr Electr Insul 2015;22:3625–32. https://doi.org/10.1109/TDEI.2015.005386.Search in Google Scholar

11. Madavan, R, Balaraman, S. Performance analysis of transformer liquid insulation system under various environmental conditions. In: International conference on condition assessment techniques in electrical systems (CATCON). Bangalore, India: IEEE; 2015: 83–6 p.10.1109/CATCON.2015.7449513Search in Google Scholar

12. Fernández, I, Delgado, F, Ortiz, F, Ortiz, A, Fernández, C, Carlos, J, et al. Thermal degradation assessment of kraft paper in power transformers insulated with natural esters. Appl Therm Eng 2016;104:129–38 https://doi.org/10.1016/j.applthermaleng.2016.05.020.Search in Google Scholar

13. Jonson, S, Saikia, N. Fatty acids profile of edible oils and fats in India. India: Centre for Science and Environment; 2009.Search in Google Scholar

14. Mariprasath, T, Kirubakaran, V. A critical review on the characteristics of alternating liquid dielectrics and feasibility study on Pongamia pinnata oil as liquid dielectrics. Renew Sustain Energy Rev elsevier 2016;65:784–99. https://doi.org/10.1016/j.rser.2016.07.036.Search in Google Scholar

15. Tang, J, Ma, S, Li, X, Zhang, Y, Pan, C, Su, J. Impact of velocity on partial discharge characteristics of moving metal particles in transformer oil using UHF technique. IEEE Trans Dielectr Electr Insul 2016;23:2207–12. https://doi.org/10.1109/tdei.2016.7556496.Search in Google Scholar

16. Tang, J, Ma, S, Zhang, X, Zhang, M, Liu, Z, Li, X, et al. Investigation of partial discharge between moving charged metal particles and electrodes in insulating oil under flow state and AC condition. IEEE Trans Dielectr Electr Insul 2016;23:1099–105. https://doi.org/10.1109/tdei.2015.005448.Search in Google Scholar

17. Corach, J, Sorichetti, PA, Romano, SD. Electrical properties of vegetable oils between 20 and 2 MHz. Int J Hydrogen Energy 2014;39:8754–8. https://doi.org/10.1016/j.ijhydene.2013.12.036.Search in Google Scholar

18. Feil, DLP, Silva, PR, Bernardon, DP, Marchesan, TB, Sperandio, M, Medeiros, LH. Development of an efficient distribution transformer using amorphous core and vegetable insulating oil. Elec Power Syst Res 2017;144:268–79. https://doi.org/10.1016/j.epsr.2016.12.015.Search in Google Scholar

19. Kumar, SS. Investigation of various natural esters insulating medium for the applications in high voltage machinery. Int J Adv Res Basic Eng Sci Technol 2018;4:2456–5717. https://doi.org/10.20238/IJARBEST.2018.04050043.Search in Google Scholar

20. Rafiq, M,Lv, YZ, Zhou, Y, Maa, KB, Wang, W, Lia, CR, et al. Use of vegetable oils as transformer oils – a review. Renew Sustain Energy Rev 2015;52:308–24. https://doi.org/10.1016/j.rser.2015.07.032.Search in Google Scholar

21. Kumar, SS, Iruthayarajan, MW, Bakrutheen, M. Analysis of vegetable liquid insulating medium for applications in high voltage transformers. In: International conference on science, engineering and management research (ICSEMR). Vellore, India: IEEE; 2014: 1–5 p.10.1109/ICSEMR.2014.7043606Search in Google Scholar

22. Kumar, SS. Examining the properties of neem oil, sunflower oil and mahua oil with antioxidants and nano powders for power transformer. Am J Electr Comput Eng 2019;3:20–9. https://doi.org/10.11648/j.ajece.20190301.13.Search in Google Scholar

23. Bandara, K, Ekanayake, C, Saha, TK, Annamalai, PK. Understanding the ageing aspects of natural ester based insulation liquid in power transformer. IEEE Trans Dielectr Electr Insul 2015;23:246–57. https://doi.org/10.1109/TDEI.2015.004744.Search in Google Scholar

24. Madavan, R, Balaraman, S, Saroja, S. Multi criteria decision making methods for ranking the liquid insulation system based on its performance characteristics with anti-oxidants under accelerated aging conditions. IET Gener, Transm Distrib 2017;11:4051–8. https://doi.org/10.1049/iet-gtd.2017.0350.Search in Google Scholar

25. Mariprasath, T, Kirubakaran, V. Pongamia pinnata as alternate liquid dielectrics in distribution transformer: a critical study on the property of viscosity. Adv Energy Power 2017;3:1–7. https://doi.org/10.1007/s12046-016-0529-0.Search in Google Scholar

26. Kumar, SS. Optimization of various natural ester oils impregnated nomex paper performance in power transformer applications under different ageing conditions. Int J Recent Technol Eng 2019;8:6245–51. https://doi.org/10.35940/ijrte.C5832.098319.Search in Google Scholar

27. Bekal, S, Bhat, NR. Bio-lubricant as an alternative to mineral oil for a CI engine—an experimental investigation with Pongamia oil as a lubricant. Energy Sources, Part A Recovery, Util Environ Eff 2012;34:1016–26. https://doi.org/10.1080/15567031003735303.Search in Google Scholar

28. Öğüt, H, Oğuz, H, Aydın, F, Ciniviz, M, Deveci, H. The effects of the use of vegetable oil based as engine lubrication oil on engine performance and emissions in diesel engines. Energy Sources, Part A Recovery, Util Environ Eff 2020;42:2381–96. https://doi.org/10.1080/15567036.2019.1668507.Search in Google Scholar

29. Madavan, R, Kumar, SS, Iruthayarajan, MW. A comparative investigation on effects of nanoparticles on characteristics of natural esters-based nanofluids. Colloid Surface 2018 Elsevier;556:30–6. https://doi.org/10.1016/j.colsurfa.2018.08.014.Search in Google Scholar

Received: 2020-06-15
Accepted: 2020-09-11
Published Online: 2020-09-22

© 2020 Walter de Gruyter GmbH, Berlin/Boston

Downloaded on 29.3.2024 from https://www.degruyter.com/document/doi/10.1515/ijeeps-2020-0128/html
Scroll to top button