Accessible Requires Authentication Published by De Gruyter February 18, 2013

Development of an atomic mobility database for liquid phase in multicomponent Al alloys: focusing on binary systems

Shaoqing Wang, Dandan Liu, Yong Du, Lijun Zhang, Qing Chen and Anders Engström

An atomic mobility database for binary liquid phase in multicomponent Al–Cu–Fe–Mg–Mn–Ni–Si–Zn alloys was established based on critically reviewed experimental and theoretical diffusion data by using DICTRA (Diffusion Controlled TRAnsformation) software. The impurity diffusivities of the elements with limited experimental data are obtained by means of the least-squares method and semi-empirical correlations. Comprehensive comparisons between the calculated and measured diffusivities indicate that most of the reported diffusivities can be well reproduced by the currently obtained atomic mobilities. The reliability of this diffusivity database is further validated by comparing the simulated concentration profiles with the measured ones, as well as the measured main inter-diffusion coefficients of liquid Al–Cu–Zn alloys with the extrapolated ones from the present binary atomic mobility database. The approach is of general validity and applicable to establish mobility databases of other liquid alloys.


d Correspondence address, Professor Dr. Yong Du, State Key Laboratory of Powder Metallurgy, Central South University, Hunan, 410083, China, Tel.: +86 731 88836213, Fax: +86 731 88710855, E-mail:

References

[1] AnderssonJ.O., ÅgrenJ.: J. Appl. Phys.72 (1992) 1350. 10.1063/1.351745 Search in Google Scholar

[2] BorgenstamA., EngströmA., HöglundL., ÅgrenJ.: J. Phase Equilib.21 (2000) 269. 10.1361/105497100770340057 Search in Google Scholar

[3] DuY., LiuS.H., ZhangL.J., XuH.H., ZhaoD.D., WangA.J., ZhouL.C.: CALPHAD35 (2011) 427. 10.1016/j.calphad.2011.06.007 Search in Google Scholar

[4] DuY., ChangY.A., HuangB.Y., GongW.P., JinZ.P., XuH.H., YuanZ.H., LiuY., HeY.H., XieF.Y.: Mater. Sci. Eng.A363 (2003) 140. 10.1016/S0921-5093(03)00624-5 Search in Google Scholar

[5] ZhangL.J., DuY., SteinbachI., ChenQ., HuangB.Y.: Acta Mater.58 (2010) 3664. 10.1016/j.actamat.2010.03.002 Search in Google Scholar

[6] HendersonJ., YangL.: Trans. AIME.221 (1961). Search in Google Scholar

[7] MeyerA.: Phys. Rev. B.81 (2010) 012102. 10.1103/PhysRevB.81.012102 Search in Google Scholar

[8] AlemanyM.M.G., GallegoL.J.: J. Chem. Phys.113 (2000) 10410. 10.1063/1.1322626 Search in Google Scholar

[9] ChauhanA.S., RaviR., ChhabraR.P.: Chem. Phys.252 (2000) 227. 10.1016/S0301-0104(99)00345-6 Search in Google Scholar

[10] JayaramC., RaviR., ChhabraR.P.: Chem. Phys. Lett.341 (2001) 179. 10.1016/S0009-2614(01)00427-4 Search in Google Scholar

[11] AhmedA.Z.Z., BhuiyanG.M.: Int. J. Mod. Phys.B16 (2002) 3837. 10.1142/S0217979202013171 Search in Google Scholar

[12] ChenF.F., ZhangH.F., QinF.X., HuZ.Q.: J. Chem. Phys.120 (2004) 1826. 10.1063/1.1636452 Search in Google Scholar

[13] SzpunarB., SmithR.W.: J. Phys.: Condens. Matter22 (2010) 035105. 2138628110.1088/0953-8984/22/3/035105 Search in Google Scholar

[14] ProtopapasP., AndersentH.C., ParleeN.A.D.: J. Chem. Phys.59 (1973) 15. 10.1063/1.1679784 Search in Google Scholar

[15] LuH.M., LiG., ZhuY.F., JiangQ.: J. Non-Cryst. Solids352 (2006) 2797. 10.1016/j.jnoncrysol.2006.03.049 Search in Google Scholar

[16] MeiJ., DavenportJ.W.: Phys. Rev. B.42 (1990) 9682. 10.1103/PhysRevB.42.9682 Search in Google Scholar

[17] YangS., SuX.P., WangJ.H., YinF.C., TangN.Y.: Metall. Mater. Trans. A40 (2009) 3108. 10.1007/s11661-009-9985-z Search in Google Scholar

[18] AlemanyM.M.G., CasasJ., ReyC., GonzalezL.E., GallegoL.J.: Phys. Rev. E.56 (1997) 6818. 10.1103/PhysRevE.56.6818 Search in Google Scholar

[19] LiG.X., LiuC.S., ZhuZ.G.: Phys. Rev. B.71 (2005) 094209. 10.1103/PhysRevB.71.094209 Search in Google Scholar

[20] WaxJ.F., AlbakiR., BretonnetJ.L.: Phys. Rev.B62 (2000) 14818. 10.1103/PhysRevB.62.14818 Search in Google Scholar

[21] LevinE.S., ZamaraevV.N., SverdlovskP.V.: Izvestiya Akademii Nauk SSSR, Metally (1976) 113.972531 Search in Google Scholar

[22] SandersP.G., AzizM.J.: J. Appl. Phys.86 (1999) 4258. 10.1063/1.371354 Search in Google Scholar

[23] ChelikowskyJ.R., TroullierN., BinggeliN.: Phys. Rev.B49 (1994) 114. 10.1103/PhysRevB.49.114 Search in Google Scholar

[24] VirkkunenR., LaasonenK., NieminenR.M.: J. Phys.: Condens. Matter3 (1991) 7455. 10.1088/0953-8984/3/38/017 Search in Google Scholar

[25] StichI., CarR., ParrinelloM.: Phys. Rev. B.44 (1991) 4262. 10.1103/PhysRevB.44.4262 Search in Google Scholar

[26] WangC.Z., ChanC.T., HoK.M.: Phys. Rev. B.45 (1992) 12227. 10.1103/PhysRevB.45.12227 Search in Google Scholar

[27] ServalliG., ColomboL.: Europhys. Lett.22 (1993) 107. 10.1209/0295-5075/22/2/006 Search in Google Scholar

[28] YuW., WangZ.Q., StroudD.: Phys. Rev. B.54 (1996) 13946. 10.1103/PhysRevB.54.13946 Search in Google Scholar

[29] KakimotoK.: J. Appl. Phys.77 (1995) 4122. 10.1063/1.359498 Search in Google Scholar

[30] BroughtonJ.Q., LiX.P.: Phys. Rev. B.35 (1987) 9120. 10.1103/PhysRevB.35.9120 Search in Google Scholar

[31] PommrichA.I., MeyerA., Holland-MoritzD., UnruhT.: Appl. Phys. Lett.92 (2008) 241922. 10.1063/1.2947592 Search in Google Scholar

[32] NachtriebN.H., FragaE., WahlC.: J. Phys. Chem.67 (1963) 2353. 10.1021/j100805a022 Search in Google Scholar

[33] LangeW., PippelW., BendelF.: Z. Phys. Chem.212 (1959) 238. Search in Google Scholar

[34] VadovicC.J., ColverC.P.: Philos. Mag.21 (1970) 971. 10.1080/14786437008238484 Search in Google Scholar

[35] IidaT., GuthrieR., TripathiN.: Metall. Mater. Trans.B37 (2006) 559. 10.1007/s11663-006-0039-2 Search in Google Scholar

[36] EjimaT., KamedaM.: J. Jpn. Inst. Met.33 (1969) 96. Search in Google Scholar

[37] LukashenkoE.E., VorobevA.K., OfengendenA.A.: Kompleksnoe Ispolzovanie Mineralnogo Syrya (1982) 39. Search in Google Scholar

[38] ShurypinP.M., ShantarinV.D.: Zh. Fiz. Khim.42 (1968) 463. Search in Google Scholar

[39] KatoM., MinowaS.: Tetsu-to-Hagane50 (1964) 2083. Search in Google Scholar

[40] LangbergD.E., NilmaniM.: Metall. Mater. Trans.B27 (1996) 780. 10.1007/BF02915607 Search in Google Scholar

[41] YangS., SuX.P., WangJ.H., YinF.C., TangN.Y., LiZ., WangX.M., ZhuZ.X., TuH., LiX.Q.: Metall. Mater. Trans.A42 (2011) 1785. 10.1007/s11661-010-0461-6 Search in Google Scholar

[42] DahlborgU., BesserM., Calvo-DahlborgM., JanssenS., JuranyiF., KramerM.J., MorrisJ.R., SordeletD.J.: J. Non-Cryst. Solids353 (2007) 3295. 10.1016/j.jnoncrysol.2007.05.074 Search in Google Scholar

[43] BrilloJ., ChathothS.M., KozaM.M., MeyerA.: Appl. Phys. Lett.93 (2008) 121905. 10.1063/1.2977863 Search in Google Scholar

[44] ZhangB., GriescheA., MeyerA.: Phys. Rev. Lett.104 (2010) 035902. 2036665910.1103/PhysRevLett.104.035902 Search in Google Scholar

[45] LeeN., CahoonJ.: J. Phase Equilib. Diffus.32 (2011) 226. 10.1007/s11669-011-9883-0 Search in Google Scholar

[46] LozovskiiV.N., PolitovaN.F., SklyarovY.I.: Zh. Fiz. Khim.50 (1976) 2137. Search in Google Scholar

[47] PetrescuM.: Z. Metallkd.61 (1970) 14. Search in Google Scholar

[48] JiM., GongX.G.: J. Phys.: Condens. Matter16 (2004) 2507. 10.1088/0953-8984/16/15/004 Search in Google Scholar

[49] MishraR.K., VenkateshR.: Chem. Phys.354 (2008) 112. 10.1016/j.chemphys.2008.09.014 Search in Google Scholar

[50] CalderonF.P., SanoN., MatsushitaY.: Metall. Mater. Trans.B2 (1971) 3325. 10.1007/BF02811613 Search in Google Scholar

[51] SaitoT., MaruyaK.: Bull. Res. Inst. Mineral Dressing Metallurgy, Tohoku Univ.12 (1956) 27. Search in Google Scholar

[52] RaoR.V.G., BandyopadhyayU.: J. Phys.: Condens. Matter1 (1989) 8621. 10.1088/0953-8984/1/44/032 Search in Google Scholar

[53] WangH.P., CaoC.D., WeiB.: Appl. Phys. Lett.84 (2004) 4062. 10.1063/1.1751618 Search in Google Scholar

[54] UemuraK.: Tetsu-to-Hagane26 (1940) 813. Search in Google Scholar

[55] HorbachJ., DasS.K., GriescheA., MachtM.P., FrohbergG., A. Meyer: Phys. Rev.B75 (2007) 174304. 10.1103/PhysRevB.75.174304 Search in Google Scholar

[56] ÅgrenJ.: Curr. Opin. Solid. State Mater. Sci.1 (1996) 355360. 10.1016/S1359-0286(96)80025-8 Search in Google Scholar

[57] DarkenL.S.: Trans. AIME175 (1948) 184. Search in Google Scholar

[58] LazarusD.: Phys. RevB.93 (1954) 973. 10.1103/PhysRev.93.973 Search in Google Scholar

[59] SwalinR.A.: J. Appl. Phys.27 (1956) 554. 10.1063/1.1722420 Search in Google Scholar

[60] EjimaT., YamamuraT., UchidaN., MatsuzakiY., NikaidoM.: J. Jpn. Inst. Met.44 (1980) 316. Search in Google Scholar

[61] SundmanB., JanssonB., AnderssonJ.O.: CALPHAD9 (1985) 153. 10.1016/0364-5916(85)90021-5 Search in Google Scholar

[62] http://www.thermocalc.com/MOBDATA.htm (2012). Search in Google Scholar

Received: 2012-10-20
Accepted: 2013-1-4
Published Online: 2013-02-18
Published in Print: 2013-08-08

© 2013, Carl Hanser Verlag, München